TM 9-2330-213-14&P
Section Il. OPERATOR/CREW PREVENTIVE MAINTENANCE
CHECKS AND SERVICES (PMCS)
Page
Paragraph Title
Number
General . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
General PMCS Procedures . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Leakage Definitions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .. . . . . . . . . . .
Operator/Crew Preventive Maintenance Checks and Services (PMCS), Table 2-1 . . . . . . . . . . . . . .
Reporting Repairs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Service Intervals . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Specific PMCS Procedures . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
2-3.
GENERAL.
a. To ensure that the M105 and M107 Series Trailers and M448 Shop Van are ready for operation at all
times, they must reinspected on a regular basis so that defects may be found before they result in serious
damage, equipment failure, or injury to personnel. This section contains systematic instructions on inspections,
adjustments, and corrections to be performed by the operator/crew.
b. While performing PMCS, read and follow all safety instructions found in the Warning Summary at the
front of this manual. Keep in mind all WARNINGS and CAUTIONS.
2-4. SERVICE INTERVALS.
Perform PMCS, found in Table 2-1, at the following intervals:
(1) Perform Before (B) PMCS just before operating the trailer.
(2) Perform During (D) PMCS while operating the trailer,
(3) Perform After (A) PMCS right after operating the trailer,
2-5. REPORTING REPAIRS.
All defects which the operator cannot fix must be reported on a DA Form 2404, Equipment Inspection and
Maintenence Worksheet, immediately after completing PMCS. If a serious problem is found, IMMEDIATELY
report it to your supervisor.
2-6. GENERAL PMCS PROCEDURES.
WARNING
Dry cleaning solvent P-D-680 is toxic and flammable. Always wear protective goggles
and gloves, and use only in a well-ventilated area. Avoid contact with skin, eyes, and
clothes, and DO NOT breathe vapors. DO NOT use near open flame or excessive
heat. The solvent's flash point is 100F-130F (38C-59C). If you become dizzy
while using cleaning solvent, immediately get fresh air and medical help. if solvent
contacts eyes, immediately wash your eyes and get medical aid.
a. Keep equipment clean. Dirt, oil, and debris may cover up a serious problem. Clean as you work and
and water on rubber, plastic, and painted surfaces.