TM 9-4120-405-13&P
WARNING
piped to the outside. Continued breathing of exhaust fumes is dangerous.
Stay clear of all exposed electrical terminals when generator set is operating.
Remove all rings, watches, and other jewelry when performing maintenance on the
generator set. Loose fitting clothing should be secured to prevent it from catching
on moving parts.
(1) Operating in Alternate Modes.
CAUTION
Reconnection Switch must be set on 120/208 V, 3-phase output or damage to air
conditioner will result.
The generator-set is pre-set for 120/208 V 3-phase output operation.
(2) Starting Generator Set.
WARNING
High noise area. May cause hearing loss. Use proper ear protection within 14 ft.
All personnel involved In the operation or maintenance of the generator set should
become thoroughly familiar with the safety precautions prior to performing
operation or maintenance procedures.
Prior to connection of load cables, make sure all switches are in OFF or OPEN
position and the generator set is not operating.
Inspect the generator set ground connection prior to starting the unit. Electrical
defects in load lines or load equipment can cause death by electrocution when
contact is made with an ungrounded system.
Do not smoke or carry an open flame when servicing the batteries or fuel tank.
Exercise extreme care to prevent electrical arcing in the area of the batteries.
Battery electrolyte contains sulfuric acid and can cause severe burns. Handle it
with care. If the electrolyte comes in contact with the body, eyes, or clothing, rinse
immediately with clean water. Avoid spilling electrolyte on painted surfaces. Do
not work alone or smoke when servicing batteries.
piped to the outside Continued breathing of exhaust fumes is dangerous.
Remove all rings, watches, and other jewelry when performing maintenance on the
generator set. Loose fitting clothing should be secured to prevent it from catching
on moving parts.
CAUTION
Do not operate in excess of 200 hours continuous with JP-4. MIL-J-5624 bulk fuel
(item 12, appendix F). Do not use either to aid in starting unit.
2-13