TM-9-4120-378-14 Air Conditioner Horizontal Compact 9 000 BTU/HR 115 Volt Single Phase 50/60 Manual

CHAPTER 1 INTRODUCTION - TM-9-4120-378-140010
Section II. EQUIPMENT DESCRIPTION - TM-9-4120-378-140011
LOCATION AND DESCRIPTION OF MAJOR COMPONENTS - TM-9-4120-378-140012
IMAGE - TM-9-4120-378-140013
Air Conditioner Model A9KH - 115P AND F9000H-1S
Section III. TECHNICAL PRINCIPLES OF OPERATION - TM-9-4120-378-140015
Bypass System
CHAPTER 2 OPERATING INSTRUCTIONS - TM-9-4120-378-140017
Section II. PREVENTIVE MAINTENANCE CHECKS AND SERVICES (PMCS) - TM-9-4120-378-140018
Table 2-1. Operator Preventive Maintenance Checks and Services (PMCS) - TM-9-4120-378-140019
Table 2-1. Operator Preventive Maintenance Checks and Services (PMCS) - Continued
Section III. OPERATION UNDER USUAL CONDITIONS - TM-9-4120-378-140021
Cooling Operation.
Cooling With Fresh Air.
Heating Operation With Fresh Air.
Section IV. OPERATION UNDER UNUSUAL CONDITIONS - TM-9-4120-378-140025
Protection.
Table 2-2. Operator Control Settings - TM-9-4120-378-140027
CHAPTER 3 OPERATOR'S MAINTENANCE INSTRUCTIONS - TM-9-4120-378-140028
AIR CONDITIONER FAILS TO OPERATE
NO HEAT OR LOW HEAT
Section III. OPERATOR MAINTENANCE INSTRUCTIONS
SCREENS AND GUARDS-SERVICE
LOUVERS-ADJUST
FRESH AIR DAMPER AND ACTUATOR-ADJUST.
CONTROL MODULE-ADJUST
CHAPTER 4 UNIT MAINTENANCE INSTRUCTIONS - TM-9-4120-378-140036
SERVICE UPON RECEIPT CHECKLIST.
Mounting.
CONNECT THE POWER SOURCE.
Section III. UNIT PREVENTIVE MAINTENANCE CHECKS AND SERVICES (PMCS) - TM-9-4120-378-140040
Table 4-1. Unit Preventive Maintenance Checks and Services (PMCS) - TM-9-4120-378-140041
Table 4-1. Unit Preventive Maintenance Checks and Services (PMCS) - Continued - TM-9-4120-378-140042
Table 4-1. Unit Preventive Maintenance Checks and Services (PMCS) - Continued - TM-9-4120-378-140043
Table 4-1. Unit Preventive Maintenance Checks and Services (PMCS) - Continued - TM-9-4120-378-140044
Table 4-1. Unit Preventive Maintenance Checks and Services (PMCS) - Continued - TM-9-4120-378-140045
Table 4-1. Unit Preventive Maintenance Checks and Services (PMCS) - Continued - TM-9-4120-378-140046
Table 4-1. Unit Preventive Maintenance Checks and Services (PMCS) - Continued - TM-9-4120-378-140047
Section IV. UNIT TROUBLESHOOTING - TM-9-4120-378-140048
UNIT TROUBLESHOOTING TABLE - TM-9-4120-378-140049
INSUFFICIENT COOLING
EVAPORATOR OR CONDENSER FAN MOTOR FAILS TO OPERATE
COMPRESSOR WILL NOT START - TM-9-4120-378-140052
INSUFFICIENT HEATING
Section V. UNIT MAINTENANCE
MAINTENANCE OF ELECTRICAL SYSTEM.
CANVAS COVER-SERVICE
CANVAS COVER- continued
PANELS-SERVICE
PANELS. - Continued - TM-9-4120-378-140059
PANELS. - Continued - TM-9-4120-378-140060
EVAPORATOR LOUVERS-SERVICE
EVAPORATOR LOUVERS. -Continued
EVAPORATOR INLET AIR FILTER-SERVICE/REPLACE
EVAPORATE INLET AIR FILTER. - Continued
MIST ELIMINATOR-SERVICE/REPLACE/REPAIR.
CONDENSER AIR DISCHARGE LOUVER AND LINKAGE-SERVICE/RE PLACE/ADJUST
CONDENSER AI R DISCHARGE LOUVER AND LINKAGE. - Continued
CONDENSER AIR DISCHARGE LOUVER AN D LINKAGE. - Continued - TM-9-4120-378-140068
CONDENSER AIR DISCHARGE LOUVER AN D LINKAGE. - Continued - TM-9-4120-378-140069
FRESH AIR DAMPER AND ACTU ATOR-INSPECT/SERVICE/RE PLACE/ADJUST
FRESH AIR DAMPER AND ACTUATOR. - Continued - TM-9-4120-378-140071
FRESH AIR DAMPER ACTUATOR. - continued
FRESH AIR DAMPER AND ACTUATOR. - Continued - TM-9-4120-378-140073
FRESH AIR DAMPER AND ACTUATOR. - continued - TM-9-4120-378-140074
FRESH AIR DAMPER AND ACTUATOR.- continued
CONDENSER DRAIN TUBE-INSPECT/SERVICE/REPLACE.
CONDENSER DRAIN TUBE. - continued
CONTROL MODULE-REPAIR/REPLACE.
CONTROL MODULE. - Continued - TM-9-4120-378-140079
CONTROL MODULE. - Continued - TM-9-4120-378-140080
CONTROL MODULE. - Continued - TM-9-4120-378-140081
CONTROL MODULE. - Continued - TM-9-4120-378-140082
CONTROL MODULE. - Continued - TM-9-4120-378-140083
CONTROL MODULE. - Continued - TM-9-4120-378-140084
CONTROL MODULE. - Continued - TM-9-4120-378-140085
CONTROL MODULE. - Continued - TM-9-4120-378-140086
CONTROL MODULE. - Continued - TM-9-4120-378-140087
CONTROL MODULE. - Continued - TM-9-4120-378-140088
CONTROL MODULE. - Continued - TM-9-4120-378-140089
JUNCTION BOX.
JUNCTION BOX. - Continued - TM-9-4120-378-140091
JUNCTION BOX. - Continued - TM-9-4120-378-140092
JUNCTION BOX. - Continued - TM-9-4120-378-140093
JUNCTION BOX. - Continued - TM-9-4120-378-140094
JUNCTION BOX. - Continued - TM-9-4120-378-140095
JUNCTION BOX. - Continued - TM-9-4120-378-140096
JUNCTION BOX. - Continued - TM-9-4120-378-140097
JUNCTION BOX. - Continued - TM-9-4120-378-140098
JUNCTION BOX WIRING HARNESS-INSPECT/TEST/REPAIR/REPLACE.
JUNCTION BOX WIRING HARNESS. - continued - TM-9-4120-378-140100
JUNCTION BOX WIRING HARNESS. - Continued - TM-9-4120-378-140101
COMPRESS OR START RELAY-INSPECT/TES T/RE PLACE.
COMPRESSOR START RELAY - Continued - TM-9-4120-378-140103
COMPRESSOR START RELAY - Continued - TM-9-4120-378-140104
UNIT WIRING HARNESS-INSPECT/TEST/REPAIR/REPLACE
UNIT WIRING HARNESS. - Continued
CAPACITORS-INSPECT/TEST/REPLACE .
CAPACITORS. -continued
CAPACITORS. - continued - TM-9-4120-378-140109
CAPACITORS. - Continued - TM-9-4120-378-140110
RECTIFIER-INSPECT/TEST/REPLACE
RECTIFIER. - Continued
TRANSFORMER-INSPECT/TEST/REPLACE.
TRANSFORMER. - Continued
EVAPORATOR FAN AND HOUSING-REPLACE.
EVAPORATOR FAN AND HOUSING. - continued - TM-9-4120-378-140116
EVAPORATOR FAN AND HOUSING. - continued - TM-9-4120-378-140117
EVAPORATOR FAN AND HOUSING. - continued - TM-9-4120-378-140118
EVAPORATOR FAN AND HOUSING. - continued - TM-9-4120-378-140119
EVAPORATOR FAN AND HOUSING. - continued - TM-9-4120-378-140120
EVAPORATOR MOTOR-INSPECT/TEST/REPLACE.
EVAPORATOR MOTOR. - Continued - TM-9-4120-378-140122
EVAPORATOR MOTOR. - Continued - TM-9-4120-378-140123
HEATER THERMOSTAT-INSPECT/TEST/REPLACE
HEATER THERMOSTAT. - continued
HEATER ELEMENTS -INSPECT/TEST/REPLACE
HEATER ELEMENTS. - continued - TM-9-4120-378-140127
HEATER ELEMENTS. - continued - TM-9-4120-378-140128
HEATER ELEMENTS. - Continued - TM-9-4120-378-140129
HEATER ELEMENTS. -continued
CONDENSER FAN. HOUSING AND MOTOR-INSPECT/TES T/REPLACE.
CONDENSER FAN, HOUSING AND MOTOR.- Continued - TM-9-4120-378-140132
CONDENSER FAN, HOUSING AND MOTOR.- Continued - TM-9-4120-378-140133
CONDENSER FAN, HOUSING AND MOTOR.- Continued - TM-9-4120-378-140134
CONDENSER FAN, HOUSING AND MOTOR.- Continued - TM-9-4120-378-140135
CONDENSER FAN, HOUSING AND MOTOR.- Continued - TM-9-4120-378-140136
EVAPORATOR COIL ASSEMBLY-SERVICE.
EVAPORATOR COIL ASSEMBLY - Continued
SOLENOID VALVES-TEST/REPAIR
SOLENOID VALVES. - Continued - TM-9-4120-378-140140
CONDENSER COIL ASSEMBLY-INSPECT/SERVICE.
CONDENSER COIL ASSEMBLY - continued
HOUSING-INSPECT/SERVICE
MAIN POWER INPUT CONNECTOR (J1) AND AUXILIARY POWER INPUT CONNECTOR (J11) NSPECT/RE PLACE.
MAIN POWER INPUT CONNECTOR (J1) AND AUXILIARY POWER INPUT CONNECTOR (J11).- Continued - TM-9-4120-378-140145
MAIN POWER INPUT CONNECTOR (J1) AND AUXILIARY POWER INPUT CONNECTOR (J11).- Continued - TM-9-4120-378-140146
INSTALLATION HARDWARE-INSPECT/REPLACE.
INSTALLATION HARDWARE.- Continued
Section VI. PREPARATION FOR STORAGE OR SHIPMENT - TM-9-4120-378-140149
Shipping Container.
CHAPTER 5 DIRECT SUPPORT MAINTENANCE INSTRUCTIONS - TM-9-4120-378-140151
COMPRESSOR WILL NOT START - TM-9-4120-378-140152
COMPRESSOR STARTS, BUT STOPS AT ONCE - "SHORT CYCLES
COMPRESSOR RUNS BUT DOES NOT COOL
COMPRESSOR EXCESSIVELY NOISY
LOW HEAT OR NO HEAT - TM-9-4120-378-140156
Section II. DIRECT SUPPORT MAINTENANCE PROCEDURES - TM-9-4120-378-140157
Refrigeration System Repair
REFRIGERATION SYSTEM SERVICIN G - (DISCHARGING)
REFRIGERATION SYSTEM SERVICING - (DISCHARGING). - Continued
REFRIGERATION SYSTEM SERVICING-(DISCHARGING). - Continued
REFRIGERATION SYSTEM SERVICING- (PURGING).
REFRIGERATION SYSTEM SERVICING-(PURGING) .- Continued
REFRIGERATION SYSTEM SERVICING - (PURGING).- Continued
REFRIGERATION SYSTEM SERVICING- (BRAZING/DEBRAZING)
REFRIGERATION SYSTEM SERVICING - (BRAZING/DEBRAZING). - Continued - TM-9-4120-378-140166
REFRIGERATION SYSTEM SERVICING - (BRAZING/DEBRAZING). - Continued - TM-9-4120-378-140167
REFRIGERATION SYSTEM SERVICING - (LEAK TEST).
REFRIGERATION SYSTEM SERVICING - (LEAK TEST). - Continued - TM-9-4120-378-140169
REFRIGERATION SYSTEM SERVICING - (LEAK TEST). - Continued - TM-9-4120-378-140170
REFRIGERATION SYSTEM SERVICING - (LEAK TEST). - Continued - TM-9-4120-378-140171
REFRIGERATION SYSTEM SERVICING- (EVACUATION).
REFRIGERATION SYSTEM SERVICING - (EVACUATION) - Continued - TM-9-4120-378-140173
REFRIGERATION SYSTEM SERVICING - (EVACUATION) - Continued - TM-9-4120-378-140174
REFRIGERATION SYSTEM SERV ICING - (CHARGING).
REFRIGERATION SYSTEM SERVICING - (CHARGING). - C o n t i n u e d
REFRIGERATION SYSTEM SERVICING - (CHARGING). - Continued - TM-9-4120-378-140177
REFRIGERATION SYSTEM SERVICING - (CHARGING). - Continued - TM-9-4120-378-140178
REFRIGERATION SYSTEM SERVICING - (PRESSURE TESTING).
REFRIGERATION SYSTEM SERVICING - (PRESSURE TESTING).- Continued
CANVAS COVER AND PANELS-REPAIR/REPLACE.
CANVAS COVER AND PANELS. - Continued - TM-9-4120-378-140182
CANVAS COVER ANDPANE LS. - Continued
CANVAS COVER AND PANELS. - Continued - TM-9-4120-378-140184
CANVAS COVER AND PANELS. - Continued - TM-9-4120-378-140185
SCREENS AND GUARDS-REPLACE/REPAIR
LOUVERS-REPLACE.
LOUVERS. - Continued
INFORMATION PLATES - REPLACE
INFORMATION PLATES. - Continued - TM-9-4120-378-140190
INFORMATION PLATES. - continued - TM-9-4120-378-140191
INFORMATION PLATES. - continued - TM-9-4120-378-140192
INFORMATION PLATES. - continued - TM-9-4120-378-140193
INFORMATION PLATES. - continued - TM-9-4120-378-140194
INFORMATION PLATES. - continued - TM-9-4120-378-140195
CONDENSER FAN MOTOR-REPAIR .
CONDENSER FAN MOTOR. - Continued - TM-9-4120-378-140197
CONDENSER FAN MOTOR. - Continued - TM-9-4120-378-140198
EVAPORATOR COIL-REPLACE/REPAIR.
EVAPORATOR COIL. - Continued - TM-9-4120-378-140200
EVAPORATOR COIL. - Continued - TM-9-4120-378-140201
EXPANSION VALVES-REPLACE.
EXPANSION VALVES. - continued - TM-9-4120-378-140203
EXPANSION VALVES. - continued - TM-9-4120-378-140204
EXPANSION VALVES. - continued - TM-9-4120-378-140205
EXPANSION VALVES. - continued - TM-9-4120-378-140206
SOLENOID VALVES-REPLACE.
SOLENOID VALVES. - continued - TM-9-4120-378-140208
SOLENOID VALVES. - continued - TM-9-4120-378-140209
PRESSURE REGULATOR VALVE-REPLACE
PRESSURE REGULATOR VALVE.- Continued
ACTUATING CYLINDER-INSPECT/ADJUST/REPLACE
ACTUATING CYLINDER. - Continued
PRESSURE SWITCHES-INSPECTS/TEST/REPLACE.
PRESSURE SWITCHES. - Continued - TM-9-4120-378-140215
PRESSURE SWITCHES. - Continued - TM-9-4120-378-140216
SERVICE VALVES-INSPECT/REPLACE
SERVICE VALVES. - Continued
PRESSURE RELIEF VALVE-INSPECT/REPLACE
PRESSURE RELIEF VALVE. - continued
CONDENSER COIL-REPLACE
CONDENSER COIL. - continued - TM-9-4120-378-140222
CONDENSER COIL. - continued - TM-9-4120-378-140223
DEHYDRATOR-INSPECT/REPLACE
DEHYDRATOR. - Continued
LIQUID INDICATOR-REPLACE.
LIQUID INDICATOR. - continued
COMPRESSOR-TEST/REPAIR/REPLACE
COMPRESSOR-TEST/REPAIR/REPLACE .- Continued
COMPRESSOR. - Continued - TM-9-4120-378-140230
COMPRESSOR. - continued - TM-9-4120-378-140231
COMPRESSOR. - continued - TM-9-4120-378-140232
COMPRESSOR. - continued - TM-9-4120-378-140233
TUBING AND FITTINGS-TEST/REPLACE
TUBING AND FITTINGS. - continued - TM-9-4120-378-140235
TUBING AND FITTINGS. - Continued - TM-9-4120-378-140236
TUBING AND FITTINGS. - Continued - TM-9-4120-378-140237
CHAPTER 6 GENERAL SUPPORT MAINTENANCE INSTRUCTIONS - TM-9-4120-378-140238
HOUSING-REPAIR .- Continued
HOUSING-REPAIR.- Continued
APPENDIX A REFERENCES - TM-9-4120-378-140241
APPENDIX B MAINTENANCE ALLOCATION CHART - TM-9-4120-378-140242
EXPLANATION OF COLUMNS IN THE MAC, SECTION II. - TM-9-4120-378-140243
EXPLANATION OF COLUMNS IN TOOL AND TEST EQUIPMENT REQUIREMENTS, SECTION HI.
Section II. MAINTENANCE ALLOCATION CHART - TM-9-4120-378-140245
Section II. MAINTENANCE ALLOCATION CHART - Continued - TM-9-4120-378-140246
Section II. MAINTENANCE ALLOCATION CHART - Continued - TM-9-4120-378-140247
Section II. MAINTENANCE ALLOCATION CHART - Continued - TM-9-4120-378-140248
Section II. MAINTENANCE ALLOCATION CHART - Continued - TM-9-4120-378-140249
Section II. MAINTENANCE ALLOCATION CHART - Continued - TM-9-4120-378-140250
Section III. TOOLS AND TEST EQUIPMENT REQUIRED
APPENDIX C COMPONENTS OF END ITEM AND BASIC ISSUE ITEMS LIST - TM-9-4120-378-140252
Section II. COMPONENTS OF END ITEM - TM-9-4120-378-140253
APPENDIX D ADDITIONAL AUTHORIZATION LIST - TM-9-4120-378-140254
APPENDIX E EXPENDABLE SUPPLIES AND MATERIALS LIST - TM-9-4120-378-140255
Section II. EXPENDABLE SUPPLIES AND MATERIALS LIST - TM-9-4120-378-140256
Section II. EXPENDABLE SUPPLIES AND MATERIALS LIST - Continued - TM-9-4120-378-140257
APPENDIX F DIAGRAMS
COMPONENT REFERENCE LIST MODEL A9KH-115P - TM-9-4120-378-140259
COMPONENT REFERENCE LIST MODEL A9KH-115P - TM-9-4120-378-140260
COMPONENT REFERENCE LIST MODEL A9KH-115P - Continued
COMPONENT REFERENCE LIST MODEL F9000H-1S
COMPONENT REFERENCE LIST MODEL F9000H-1S - CONTINUED
COMPONENT REFERENCE LIST MODEL F9000H1S
TM-9-4120-378-14 Air Conditioner Horizontal Compact 9 000 BTU/HR 115 Volt Single Phase 50/60 Manual

Western Governors University

Privacy Statement
Press Release
Contact

Integrated Publishing, Inc. - A (SDVOSB) Service Disabled Veteran Owned Small Business