Figure 1-1. Air Conditioner: Trailer-Mounted, Generator-Set-Powered, 18,000 BTU/HR.
CHAPTER 1 INTRODUCTION - TM-9-4120-405-13-P0009
Section II. EQUIPMENT DESCRIPTION AND DATA - TM-9-4120-405-13-P0010
EQUIPMENT DATA. - TM-9-4120-405-13-P0011
LOCATION AND DESCRIPTION OF MAJOR COMPONENTS - TM-9-4120-405-13-P0012
Figure 1-2. Location of Major Components. - TM-9-4120-405-13-P0013
Section III. TECHNICAL PRINCIPLES OF OPERATION - TM-9-4120-405-13-P0014
CHAPTER 2 OPERATING INSTRUCTIONS - TM-9-4120-405-13-P0015
Section I. DESCRIPTION AND USE OF OPERATOR'S CONTROLS AND INDICATORS - TM-9-4120-405-13-P0016
Figure 2-1. Operator Controls and Indicators (Sheet 1 of 2).
Figure 2-1. Operator Controls and Indicators (Sheet 2 of 2).
Section II. OPERATOR PREVENTIVE MAINTENANCE CHECKS AND SERVICES (PMCS) - TM-9-4120-405-13-P0019
Table 2-1. Operator Preventive Maintenance Checks and Services - TM-9-4120-405-13-P0020
Table 2-1. Operator Preventive Maintenance Checks and Services (cont.) - TM-9-4120-405-13-P0021
Table 2-1. Operator Preventive Maintenance Checks and Services (cont.) - TM-9-4120-405-13-P0022
Table 2-1. Operator Preventive Maintenance Checks and Services (cont.) - TM-9-4120-405-13-P0023
Table 2-1. Operator Preventive Maintenance Checks and Services (cont.) - TM-9-4120-405-13-P0024
Section III. OPERATION UNDER USUAL CONDITIONS - TM-9-4120-405-13-P0025
GENERAL OPERATING PROCEDURES. - TM-9-4120-405-13-P0026
GENERAL OPERATING PROCEDURES. (CONT)
Starting Generator Set.
Figure 2-2. Transfer Switch.
Table 2-2. Reconnection Switch Positions
Table 2-3. Initial Operator Control Settings
GENERAL OPERATION OF CONTROLS.
OPERATION IN HI HEAT MODE.
SHUTDOWN.
INFORMATION PLATES AND MARKINGS
Figure 2-5. Location of Information Plates and Markings.
Figure 2-6. Identification of Information Plates.
Figure 2-7. Identification of Markings.
Section IV. OPERATION UNDER UNUSUAL CONDITIONS - TM-9-4120-405-13-P0039
OPERATION IN EXTREME COLD - TM-9-4120-405-13-P0040
OPERATION IN DUSTY OR SANDY CONDITIONS. - TM-9-4120-405-13-P0041
OPERATION IN UNUSUALLY WET CONDITIONS.
OPERATION UNDER EMERGENCY CONDITIONS. - TM-9-4120-405-13-P0043
CHAPTER 3 OPERATOR MAINTENANCE - TM-9-4120-405-13-P0044
Figure 3-1. Lubrication Order, Generator-Set (Sheet 1 of 2).
Figure 3-1. Lubrication Order, Generator-Set (Sheet 2 of 2).
Figure 3-2. Drain Hose Connection, Oil.
Table 3-1. Operator Troubleshooting.
REDUCE HEATING CAPACITY.
ENGINE CRANKS NORMALLY BUT FAILS TO START.
ENGINE RUNS BUT EMITS BLACK SMOKE IN EXHAUST.
GENERATOR SUPPLIES NO VOLTAGE TO LOAD.
Section III. OPERATOR MAINTENANCE PROCEDURES - TM-9-4120-405-13-P0053
CHAPTER 4 UNIT MAINTENANCE INSTRUCTIONS - TM-9-4120-405-13-P0054
Section I. UNIT LUBRICATION INSTRUCTIONS
Figure 4-1. Lubrication Order, Trailer (Sheet 1 of 3).
Figure 4-1. Lubrication Order, Trailer (Sheet 2 of 3).
Figure 4-1. Lubrication Order, Trailer (Sheet 3 of 3).
Section II. REPAIR PARTS, SPECIAL TOOLS, TMDE, AND SUPPORT EQUIPMENT - TM-9-4120-405-13-P0059
CHECKING UNPACKED EQUIPMENT - TM-9-4120-405-13-P0060
Figure 4-2. Site Preparation.
Figure 4-3. Front Support Leg.
INSTALLATION INSTRUCTIONS - TM-9-4120-405-13-P0063
Figure 4-4. Leg Prop Assembly.
Figure 4-5. Shelter Adapters.
GROUNDING.
Figure 4-6. Grounding Trailer-Mounted, Generator-Set Powered, Air Conditioner.
Removal. - TM-9-4120-405-13-P0068
Remove ground rod as follows:
FLEXIBLE DUCTS
Figure 4-7. Flexible Duct Attachment to Adapters.
Figure 4-8. Fire Extinguisher.
To disconnect auxiliary fuel source, perform the following steps.
Figure 4-10. Auxiliary Fuel Line Connection.
Section IV. UNIT PREVENTIVE MAINTENANCE CHECKS AND SERVICES (PMCS) - TM-9-4120-405-13-P0075
Section V. UNIT TROUBLESHOOTING PROCEDURES - TM-9-4120-405-13-P0076
Table 4-2. Unit Troubleshooting.
Section VI. UNIT MAINTENANCE PROCEDURES - TM-9-4120-405-13-P0078
POWER CABLE AND GROUND WIRES
Figure 4-11. Power Cable and Ground Wires (Sheet 1 of 3).
Figure 4-11. Power Cable and Ground Wires (Sheet 2 of 3).
Figure 4-11. Power Cable and Ground Wires (Sheet 3 of 3).
INSTALLATION. - TM-9-4120-405-13-P0083
STORAGE AND ACCESSORY BOXES
Figure 4-12. Box, Storage and Accessory.
MOUNTING BRACKET, FIRE EXTINGUISHER
Figure 4-13. Mounting Bracket, Fire Extinguisher.
ADAPTER, SUPPLY AND RETURN DUCT
Figure 4-14. Adapters, Supply and Return Duct.
REPAIR. - TM-9-4120-405-13-P0090
COVER, ADAPTER END
LEG DROP ASSEMBLY
Figure 4-16. Leg Prop Assembly.
FENDER
Figure 4-17. Fender.
PLATES, DATA
Figure 4-18. Plates, Data.
REFLECTOR AND BRACKET
Figure 4-19. Reflector and Bracket.
CLAMPS, CABLE
Figure 4-20. Clamps, Cable.
STACK, EXHAUST
Figure 4-21. Stack, Exhaust.
HOSE, DRAIN EXTENSION
Figure 4-22. Hose, Drain Extension.
FILTER, RETURN AIR
Figure 4-23. Filter, Return Air.
TERMINAL GROUND
Figure 4-24. Terminal, Ground.
Section VII. PREPARATION FOR STORAGE OR SHIPMENT - TM-9-4120-405-13-P0110
Long Term or Flyable Storage (Indefinite Time). - TM-9-4120-405-13-P0111
CHAPTER 5 DIRECT SUPPORT MAINTENANCE - TM-9-4120-405-13-P0112
AIR CONDITIONER. - TM-9-4120-405-13-P0113
Figure 5-1. Air Conditioner.
DISASSEMBLY. - TM-9-4120-405-13-P0115
Figure 5-3. Replacement Air Conditioner.
ASSEMBLY. - TM-9-4120-405-13-P0117
GENERATOR SET
Figure 5-4. Generator Set.
MOUNTING RAILS
Figure 5-5. Mounting Rails.
APPENDIX A REFERENCES - TM-9-4120-405-13-P0122
APPENDIX B MAINTENANCE ALLOCATION CHART - TM-9-4120-405-13-P0123
EXPLANATION OF COLUMNS IN THE MAC
EXPLANATION OF COLUMNS IN TOOL AND TEST EQUIPMENT REQUIREMENTS - TM-9-4120-405-13-P0125
Section II. MAINTENANCE ALLOCATION CHART - TM-9-4120-405-13-P0126
Section II. MAINTENANCE ALLOCATION CHART, cont.
Section III. SPECIAL TOOLS AND TEST EQUIPMENT REQUIREMENT
Section IV. REMARKS - TM-9-4120-405-13-P0129
APPENDIX C UNIT AND DIRECT SUPPORT MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS LIST
Source Code - TM-9-4120-405-13-P0131
Maintenance Code - TM-9-4120-405-13-P0132
Recoverability Code - TM-9-4120-405-13-P0133
EXPLANATION OF COLUMNS - TM-9-4120-405-13-P0134
HOW TO LOCATE REPAIR PARTS. - TM-9-4120-405-13-P0135
ABBREVIATIONS - TM-9-4120-405-13-P0136
Figure C-1. Electrical Connectors (Sheet 1 of 2).
Figure C-1. Electrical Connectors (Sheet 2 of 2).
GROUP 01 ELECTRICAL CONNECTORS
Figure C-2. Storage and Accessory Boxes.
GROUP 02 STORAGE AND ACCESSORY
Figure C-3. Fire Extinguisher Bracket.
GROUP 03 FIRE EXTINGUISHER BRACKET
Figure C-4. Duct Adapters.
GROUP 04 DUCT ADAPTERS
Figure C-5. Leg Prop Assembly.
GROUP 05 LEG PROP ASSEMBLY
Figure C-6. Fenders.
GROUP 06 FENDERS
Figure C-7. Data Plates.
GROUP 07 ACCESSORIES - TM-9-4120-405-13-P0151
Figure C-8. Reflectors.
GROUP 07 ACCESSORIES - TM-9-4120-405-13-P0153
Figure C-9. Cable Clamps.
GROUP 07 ACCESSORIES - TM-9-4120-405-13-P0155
Figure C-10. Exhaust Stack
GROUP 07 ACCESSORIES - TM-9-4120-405-13-P0157
Figure C-11. Drain Hose Extension.
GROUP 07 ACCESSORIES - TM-9-4120-405-13-P0159
Figure C-12. Return Air Filter.
GROUP 07 ACCESSORIES - TM-9-4120-405-13-P0161
Figure C-13. Air Conditioner and Mounting Rails (Sheet 1 of 2)
Figure C-13. Air Conditioner and Mounting Rails (Sheet 2 of 2).
GROUP 08 AIR CONDITIONER AND MOUNT RAILS
Figure C-14. Generator Set and Mounting Rails (Sheet 1 of 2).
Figure C-14. Generator Set and Mounting Rails (Sheet 2 of 2).
GROUP 09 GENERATOR SET AND MOUNT RAILS
Figure C-15. Trailer Assembly.
GROUP 10 TRAILER ASSEMBLY
GROUP 11 BULK ITEMS
NATIONAL STOCK NUMBER INDEX - TM-9-4120-405-13-P0171
PART NUMBER INDEX - TM-9-4120-405-13-P0172
PART NUMBER INDEX - TM-9-4120-405-13-P0173
FIGURE AND ITEM NUMBER INDEX - TM-9-4120-405-13-P0174
FIGURE AND ITEM NUMBER INDEX - TM-9-4120-405-13-P0175
APPENDIX D COMPONENTS OF END ITEM AND BASIC ISSUE ITEMS LIST - TM-9-4120-405-13-P0176
Figure D-1. Components of End Items (Sheet 1 of 2).
Figure D-1. Components of End Items (Sheet 2 of 2).
Section II. COMPONENTS OF END ITEM - TM-9-4120-405-13-P0179
Section III. BASIC ISSUE ITEMS - TM-9-4120-405-13-P0180
APPENDIX E ADDITIONAL AUTHORIZATION LIST
APPENDIX F EXPENDABLE/DURABLE SUPPLIES AND MATERIALS LIST - TM-9-4120-405-13-P0182
Section II. EXPENDABLE/DURABLE SUPPLIES AND MATERIALS LIST - TM-9-4120-405-13-P0183
Section II. EXPENDABLE/DURABLE SUPPLIES AND MATERIALS LIST, Cont.
APPENDIX G TORQUE LIMITS - TM-9-4120-405-13-P0185
TM-9-4120-405-13-P Air Conditioner: Trailer-Mounted Generator-Set-Powered 18 000 BTU/HR (NSN 4120-00-930-5700) Manual
CHAPTER 1 INTRODUCTION - TM-9-4120-405-13-P0009
Section II. EQUIPMENT DESCRIPTION AND DATA - TM-9-4120-405-13-P0010
EQUIPMENT DATA. - TM-9-4120-405-13-P0011
LOCATION AND DESCRIPTION OF MAJOR COMPONENTS - TM-9-4120-405-13-P0012
Figure 1-2. Location of Major Components. - TM-9-4120-405-13-P0013
Section III. TECHNICAL PRINCIPLES OF OPERATION - TM-9-4120-405-13-P0014
CHAPTER 2 OPERATING INSTRUCTIONS - TM-9-4120-405-13-P0015
Section I. DESCRIPTION AND USE OF OPERATOR'S CONTROLS AND INDICATORS - TM-9-4120-405-13-P0016
Figure 2-1. Operator Controls and Indicators (Sheet 1 of 2).
Figure 2-1. Operator Controls and Indicators (Sheet 2 of 2).
Section II. OPERATOR PREVENTIVE MAINTENANCE CHECKS AND SERVICES (PMCS) - TM-9-4120-405-13-P0019
Table 2-1. Operator Preventive Maintenance Checks and Services - TM-9-4120-405-13-P0020
Table 2-1. Operator Preventive Maintenance Checks and Services (cont.) - TM-9-4120-405-13-P0021
Table 2-1. Operator Preventive Maintenance Checks and Services (cont.) - TM-9-4120-405-13-P0022
Table 2-1. Operator Preventive Maintenance Checks and Services (cont.) - TM-9-4120-405-13-P0023
Table 2-1. Operator Preventive Maintenance Checks and Services (cont.) - TM-9-4120-405-13-P0024
Section III. OPERATION UNDER USUAL CONDITIONS - TM-9-4120-405-13-P0025
GENERAL OPERATING PROCEDURES. - TM-9-4120-405-13-P0026
GENERAL OPERATING PROCEDURES. (CONT)
Starting Generator Set.
Figure 2-2. Transfer Switch.
Table 2-2. Reconnection Switch Positions
Table 2-3. Initial Operator Control Settings
GENERAL OPERATION OF CONTROLS.
OPERATION IN HI HEAT MODE.
SHUTDOWN.
INFORMATION PLATES AND MARKINGS
Figure 2-5. Location of Information Plates and Markings.
Figure 2-6. Identification of Information Plates.
Figure 2-7. Identification of Markings.
Section IV. OPERATION UNDER UNUSUAL CONDITIONS - TM-9-4120-405-13-P0039
OPERATION IN EXTREME COLD - TM-9-4120-405-13-P0040
OPERATION IN DUSTY OR SANDY CONDITIONS. - TM-9-4120-405-13-P0041
OPERATION IN UNUSUALLY WET CONDITIONS.
OPERATION UNDER EMERGENCY CONDITIONS. - TM-9-4120-405-13-P0043
CHAPTER 3 OPERATOR MAINTENANCE - TM-9-4120-405-13-P0044
Figure 3-1. Lubrication Order, Generator-Set (Sheet 1 of 2).
Figure 3-1. Lubrication Order, Generator-Set (Sheet 2 of 2).
Figure 3-2. Drain Hose Connection, Oil.
Table 3-1. Operator Troubleshooting.
REDUCE HEATING CAPACITY.
ENGINE CRANKS NORMALLY BUT FAILS TO START.
ENGINE RUNS BUT EMITS BLACK SMOKE IN EXHAUST.
GENERATOR SUPPLIES NO VOLTAGE TO LOAD.
Section III. OPERATOR MAINTENANCE PROCEDURES - TM-9-4120-405-13-P0053
CHAPTER 4 UNIT MAINTENANCE INSTRUCTIONS - TM-9-4120-405-13-P0054
Section I. UNIT LUBRICATION INSTRUCTIONS
Figure 4-1. Lubrication Order, Trailer (Sheet 1 of 3).
Figure 4-1. Lubrication Order, Trailer (Sheet 2 of 3).
Figure 4-1. Lubrication Order, Trailer (Sheet 3 of 3).
Section II. REPAIR PARTS, SPECIAL TOOLS, TMDE, AND SUPPORT EQUIPMENT - TM-9-4120-405-13-P0059
CHECKING UNPACKED EQUIPMENT - TM-9-4120-405-13-P0060
Figure 4-2. Site Preparation.
Figure 4-3. Front Support Leg.
INSTALLATION INSTRUCTIONS - TM-9-4120-405-13-P0063
Figure 4-4. Leg Prop Assembly.
Figure 4-5. Shelter Adapters.
GROUNDING.
Figure 4-6. Grounding Trailer-Mounted, Generator-Set Powered, Air Conditioner.
Removal. - TM-9-4120-405-13-P0068
Remove ground rod as follows:
FLEXIBLE DUCTS
Figure 4-7. Flexible Duct Attachment to Adapters.
Figure 4-8. Fire Extinguisher.
To disconnect auxiliary fuel source, perform the following steps.
Figure 4-10. Auxiliary Fuel Line Connection.
Section IV. UNIT PREVENTIVE MAINTENANCE CHECKS AND SERVICES (PMCS) - TM-9-4120-405-13-P0075
Section V. UNIT TROUBLESHOOTING PROCEDURES - TM-9-4120-405-13-P0076
Table 4-2. Unit Troubleshooting.
Section VI. UNIT MAINTENANCE PROCEDURES - TM-9-4120-405-13-P0078
POWER CABLE AND GROUND WIRES
Figure 4-11. Power Cable and Ground Wires (Sheet 1 of 3).
Figure 4-11. Power Cable and Ground Wires (Sheet 2 of 3).
Figure 4-11. Power Cable and Ground Wires (Sheet 3 of 3).
INSTALLATION. - TM-9-4120-405-13-P0083
STORAGE AND ACCESSORY BOXES
Figure 4-12. Box, Storage and Accessory.
MOUNTING BRACKET, FIRE EXTINGUISHER
Figure 4-13. Mounting Bracket, Fire Extinguisher.
ADAPTER, SUPPLY AND RETURN DUCT
Figure 4-14. Adapters, Supply and Return Duct.
REPAIR. - TM-9-4120-405-13-P0090
COVER, ADAPTER END
LEG DROP ASSEMBLY
Figure 4-16. Leg Prop Assembly.
FENDER
Figure 4-17. Fender.
PLATES, DATA
Figure 4-18. Plates, Data.
REFLECTOR AND BRACKET
Figure 4-19. Reflector and Bracket.
CLAMPS, CABLE
Figure 4-20. Clamps, Cable.
STACK, EXHAUST
Figure 4-21. Stack, Exhaust.
HOSE, DRAIN EXTENSION
Figure 4-22. Hose, Drain Extension.
FILTER, RETURN AIR
Figure 4-23. Filter, Return Air.
TERMINAL GROUND
Figure 4-24. Terminal, Ground.
Section VII. PREPARATION FOR STORAGE OR SHIPMENT - TM-9-4120-405-13-P0110
Long Term or Flyable Storage (Indefinite Time). - TM-9-4120-405-13-P0111
CHAPTER 5 DIRECT SUPPORT MAINTENANCE - TM-9-4120-405-13-P0112
AIR CONDITIONER. - TM-9-4120-405-13-P0113
Figure 5-1. Air Conditioner.
DISASSEMBLY. - TM-9-4120-405-13-P0115
Figure 5-3. Replacement Air Conditioner.
ASSEMBLY. - TM-9-4120-405-13-P0117
GENERATOR SET
Figure 5-4. Generator Set.
MOUNTING RAILS
Figure 5-5. Mounting Rails.
APPENDIX A REFERENCES - TM-9-4120-405-13-P0122
APPENDIX B MAINTENANCE ALLOCATION CHART - TM-9-4120-405-13-P0123
EXPLANATION OF COLUMNS IN THE MAC
EXPLANATION OF COLUMNS IN TOOL AND TEST EQUIPMENT REQUIREMENTS - TM-9-4120-405-13-P0125
Section II. MAINTENANCE ALLOCATION CHART - TM-9-4120-405-13-P0126
Section II. MAINTENANCE ALLOCATION CHART, cont.
Section III. SPECIAL TOOLS AND TEST EQUIPMENT REQUIREMENT
Section IV. REMARKS - TM-9-4120-405-13-P0129
APPENDIX C UNIT AND DIRECT SUPPORT MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS LIST
Source Code - TM-9-4120-405-13-P0131
Maintenance Code - TM-9-4120-405-13-P0132
Recoverability Code - TM-9-4120-405-13-P0133
EXPLANATION OF COLUMNS - TM-9-4120-405-13-P0134
HOW TO LOCATE REPAIR PARTS. - TM-9-4120-405-13-P0135
ABBREVIATIONS - TM-9-4120-405-13-P0136
Figure C-1. Electrical Connectors (Sheet 1 of 2).
Figure C-1. Electrical Connectors (Sheet 2 of 2).
GROUP 01 ELECTRICAL CONNECTORS
Figure C-2. Storage and Accessory Boxes.
GROUP 02 STORAGE AND ACCESSORY
Figure C-3. Fire Extinguisher Bracket.
GROUP 03 FIRE EXTINGUISHER BRACKET
Figure C-4. Duct Adapters.
GROUP 04 DUCT ADAPTERS
Figure C-5. Leg Prop Assembly.
GROUP 05 LEG PROP ASSEMBLY
Figure C-6. Fenders.
GROUP 06 FENDERS
Figure C-7. Data Plates.
GROUP 07 ACCESSORIES - TM-9-4120-405-13-P0151
Figure C-8. Reflectors.
GROUP 07 ACCESSORIES - TM-9-4120-405-13-P0153
Figure C-9. Cable Clamps.
GROUP 07 ACCESSORIES - TM-9-4120-405-13-P0155
Figure C-10. Exhaust Stack
GROUP 07 ACCESSORIES - TM-9-4120-405-13-P0157
Figure C-11. Drain Hose Extension.
GROUP 07 ACCESSORIES - TM-9-4120-405-13-P0159
Figure C-12. Return Air Filter.
GROUP 07 ACCESSORIES - TM-9-4120-405-13-P0161
Figure C-13. Air Conditioner and Mounting Rails (Sheet 1 of 2)
Figure C-13. Air Conditioner and Mounting Rails (Sheet 2 of 2).
GROUP 08 AIR CONDITIONER AND MOUNT RAILS
Figure C-14. Generator Set and Mounting Rails (Sheet 1 of 2).
Figure C-14. Generator Set and Mounting Rails (Sheet 2 of 2).
GROUP 09 GENERATOR SET AND MOUNT RAILS
Figure C-15. Trailer Assembly.
GROUP 10 TRAILER ASSEMBLY
GROUP 11 BULK ITEMS
NATIONAL STOCK NUMBER INDEX - TM-9-4120-405-13-P0171
PART NUMBER INDEX - TM-9-4120-405-13-P0172
PART NUMBER INDEX - TM-9-4120-405-13-P0173
FIGURE AND ITEM NUMBER INDEX - TM-9-4120-405-13-P0174
FIGURE AND ITEM NUMBER INDEX - TM-9-4120-405-13-P0175
APPENDIX D COMPONENTS OF END ITEM AND BASIC ISSUE ITEMS LIST - TM-9-4120-405-13-P0176
Figure D-1. Components of End Items (Sheet 1 of 2).
Figure D-1. Components of End Items (Sheet 2 of 2).
Section II. COMPONENTS OF END ITEM - TM-9-4120-405-13-P0179
Section III. BASIC ISSUE ITEMS - TM-9-4120-405-13-P0180
APPENDIX E ADDITIONAL AUTHORIZATION LIST
APPENDIX F EXPENDABLE/DURABLE SUPPLIES AND MATERIALS LIST - TM-9-4120-405-13-P0182
Section II. EXPENDABLE/DURABLE SUPPLIES AND MATERIALS LIST - TM-9-4120-405-13-P0183
Section II. EXPENDABLE/DURABLE SUPPLIES AND MATERIALS LIST, Cont.
APPENDIX G TORQUE LIMITS - TM-9-4120-405-13-P0185
TM-9-4120-405-13-P Air Conditioner: Trailer-Mounted Generator-Set-Powered 18 000 BTU/HR (NSN 4120-00-930-5700) Manual
