--
Table
IV.
Troubleshooting-Continued
Probable
t
Probable
Corrective action
maintenance
dwell
personnel for
meter,
. Other causes --
Refer other
correction.
and vacu-
causes to field
um meter
maintenance
do not
personnel.
register
Replace incan-
2. Work lamp
same
descent lamp
fails to
lamp burned
when dis-
out.
light.
tributor
b. Refer other
I. Other causes --
is tested
causes to field
the
maintenance
time.
personnel.
Straighten elec-
a. Electrical clips
6. Electrical
Lubricate tester
3. Tester
trical clips
clips do
bent from
require lubri-
chatters
not make
rough usage.
cation.
or vi-
5. Clean electrical
b. Electrical clips
positive
b. Refer other
Other causes --
brates
burned from
causes to field
under
arcing.
maintenance
speed.
Replace electri-
c. Electrical clips
personnel.
broken by
Vacuum pump
Adjust vacuum
4. Vacuum
rough usage.
needs adjust-
pump
Replace electri-
a. Electrical cable
7. Electrical
ment.
to create
cal cable
cable
nipples
b. Refer other
Other causes --
desired
crushed or
nipples
causes to field
vacuum
cut.
do not
maintenance
control to
b. Replace electri-
Electrical cable
insulate
personnel.
distribu-
cal cable
nipples
electrical
tor.
deteriorated.
clips
----------------
Refer
5. Speed me-
properly.
tion to field
ter, cam
V. ELECTRICAL CLIPS AND ELECTRICAL CABLE NIPPLES
terminal screw and remove the electrical
clips. Pull the electrical cable nipples
There are three electrical clips (fig.
off the leads.
12) on the tester, one on each of the two
c. Cleaning and Inspection.
coil leads and one on the cam angle lead.
(1)
Using a stiff bristle
The clips are alligator type and are at-
brush remove the burns, rust,
tached to the leads with a single screw
and corrosion from the electrical
terminal. The electrical cable nipples
clips. Clean the electrical cable
or plastic, are 2-37/64 long overall, and
completely cover the electrical clips.
(2) Inspection. Inspect the electrical
The nipples are easily slipped up the
clips for breaks, cracks, and dis-
cable to allow access to the terminals
tortion. Inspect the electrical ca-
on the electrical clips.
ble nipples for cracks and deteri-
oration.
d. Repair. Using pliers straighten bent
Organ
main-
a.
electrical clips and aline the serrated
is limited to repair or removal,
jaws so they will interlock.
installation, and replacement of the elec-
e. Installation. Slide the electrical ca-
trical clips and replacement of the elec-
ble nipples, 5175-383-1318, over the
trical cable nipples.
leads and up far enough to expose the tip
Slide the electrical cable
of the lead for attaching the electrical
nipples up the leads far enough
expose
electrical clips (5940-
clips. Attach
entire electrical clips, loosen the
186-8928 to the cam angle lead and